嚴禁蒸汽伴熱和電伴熱混用于一體，加熱帶安裝時不得破壞絕緣層，應緊貼于被加熱體以提高熱效率。若被伴熱體為非金屬體，應用黏膠帶增大接觸傳熱面積，除霜電熱管報價，以尼龍扎帶固定，嚴禁用金屬絲綁扎。 法蘭處介質易泄漏，纏繞電熱帶時應避開其正下方。電熱帶一端接入電源，另一端線芯嚴禁短接或與導電物質接觸并剪切為“V'型，必須使用配套的封頭嚴密套封;防水防爆場合應有配套的防爆接線盒和終端子。接線后應用硅橡膠密封(使用屏蔽層的電熱帶終端處須將屏蔽層剝離10cm，以防短路);安裝時應逐一測量伴熱點的絕緣，屏蔽層必須接地。

防爆電加熱器的內部高壓系統可以向DCS系統提供加熱器處于運行、高溫、故障、停運等報警信號，也可以接受DCS發出的自動、停運等操作口號，而且對電加熱器系統增設了可靠安全的監測裝置，但是這種 防爆電加熱器價格參考相對來講也較高。電氣設備有多個關聯的接口，可以隨時對導熱油泵、導熱油的溫度流量、內部高溫電壓的壓力進行有效的監控。從而實現防爆電加熱器更節能、更環保、更的理想化改革。

在使用時，不可以將物品放在電加熱器附近，必須要保持一定的安全距離。電加熱器必須放在不導熱的不燃材料基座上；電加熱器導線的安全截流量必須滿足電加熱器的容量要求，工業用電加熱器在任何情況下都要裝置單獨的電路。導線必須要安裝插頭，不可以將電加熱器線頭直接插入插座;電加熱器導線老化破損應及時更換，電路中沒有安裝熔斷器的電加熱器不得使用；電加熱器使用的時候必須有人看管，除霜電熱管廠，離開時應拔掉插頭，本溪除霜電熱管，在使用過程中，除霜電熱管批發，若遇停電，也應及時將電加熱器插頭拔出，不要遺忘。對于多次修理的電阻絲，建議不再使用，應更換新的電阻絲。物品嚴禁用電加熱器烘干；電烘箱應有控制溫度的裝置，既要防止溫度過高，又要防止電加熱器烘烤時間過長。